Windshield Replacement in Mooresville, NC

Charlotte Mobile Auto Glass is the mobile service of Impex Auto Glass for Charlotte and the towns along I-77. Requests from this page go straight to Impex.

Mooresville and the Iredell side of the lake

Mooresville sits in southern Iredell County, about 25 miles north of Charlotte, with Lake Norman 3 to 8 miles west of the town center. The 2020 census counted 50,193 people. The town is widely known as Race City USA, home to many NASCAR teams and drivers, and Lowe’s has its corporate headquarters here. Besides I-77 on the west side of town, US 21, NC 3, NC 115, NC 150, NC 152 and NC 801 all pass through or around it.

Langtree and the south end

Exit 31 at Langtree Road is the first Mooresville exit after the causeway, and exit 33 takes US 21 north toward the lake. Apartment communities and office lots near the interstate are common places for a mobile visit, with the manager’s agreement where the lot is private.

Brawley School Road

Exit 35 at Brawley School Road opened on June 28, 2013 and connects the interstate with the neighborhoods to the west toward the lake. Lakeside lots often slope toward the water, so a garage or a flat street nearby may be the better place for the car on the day.

NC 150 and the town center

Exit 36 at NC 150 is where the I-77 Express Lanes end, and the road heads west toward Lincolnton and east into Mooresville. NC 150 also runs on to Denver on the far side of the lake, which the van covers too. The older streets of the town center, along NC 115 and NC 152, have homes with driveways that suit a windshield job well.

Why Mooresville windshields take a beating

Most drivers in Mooresville spend a lot of time on I-77. The I-77 Express Lanes run 26 miles in the median from Charlotte to NC 150, and the general lanes carry commuters and trucks toward the city every morning. Stones come off tires, truck beds and road edges. North Carolina’s G.S. 20-116(g) requires trucks over 7,500 pounds carrying rock, gravel or stone to keep the load six inches below the walls and covered, but a stone from a tire tread is not covered by any tarp.

Boat trailers are part of life near the lake too. A long tow on gravel launch roads and a windshield that takes a stone on the way home is a familiar story. Small chips can often be filled at the car; see mobile windshield repair in Charlotte for what can be repaired. Bigger cracks mean a new windshield.

The windshield visit in Mooresville

1. Book with the VIN. Impex uses VIN-based verification so the right windshield is ordered, with the right camera bracket and sensors.
2. Pick the spot. A level driveway, a garage, a covered parking row or a work lot, with room to open both front doors fully.
3. The swap. The old windshield is cut out, the frame cleaned and prepared, fresh urethane laid and the new glass set.
4. Calibration. Impex calibrates the forward camera on site after the glass when the vehicle requires it.
5. Drive-away. You are told when it is safe to drive. Impex says most cars are back on the road within two hours.

Impex says calibration takes between 30 minutes and 2 hours and that its technicians can do both static and dynamic calibration in one visit. A dynamic calibration is done on the road at or below a set speed, which I-CAR notes may need dry roads without heavy traffic or tight curves. The flat stretches of NC 150 or US 21 away from the rush are often easier than the interstate for that drive.

Auto glass in Mooresville besides the windshield

Side and door windows are usually replaced in 30 to 60 minutes and can be driven straight away, by Impex’s figures. Back glass takes one to two hours, with the rear defroster left off for 24 hours afterwards. Impex also performs radar calibration on site, without a separate dealership appointment, for cars whose front radar has been disturbed by bumper or grille work. Radar usually sits in the bumper or grille, so most windshield jobs need only the camera calibrated.

Trucks, work vehicles and fleets

Mooresville has plenty of work trucks and company vehicles, from trades to the racing shops. Impex describes itself as fleet focused and says it stocks glass that fleets commonly need, with a stated aim of minimizing downtime. A mobile visit at the yard or the shop floor keeps the truck close to where it works.

Weather on the lake side

Wind off the water and rain blowing across open lots are the two things that move a mobile job here. The glass and the frame need to be dry for the adhesive, and the Auto Glass Safety Council says drive-away time varies with the atmospheric conditions. A garage or a covered deck lets most jobs go ahead; otherwise Impex will offer another time.

Right after the glass breaks

A crack that appears on the way home from Charlotte does not need a dash to a shop. If the windshield is still in one piece and the crack is out of your line of sight, drive home gently, park and call. Keep the defroster off the crack, do not slam the doors and stay off rough roads until the visit. If the glass is broken through, or a side or back window has shattered, take valuables out of the car, cover the opening with heavy plastic taped to the paint and keep the car under cover if you can. Then call Impex with the address and the vehicle.

Fitting the visit into a Mooresville day

Because the van comes to the car, the visit can follow your day rather than the other way round. Plenty of Mooresville drivers commute south on I-77, so a job at the workplace lot in Charlotte or Huntersville can be easier than one at home; others prefer the driveway on a day working from home. Impex lists no-contact service options, so you can hand over the keys and carry on. Tell Impex when you book where the car will be and for how long, and whether it sits under cover. That is usually enough to plan the visit and to say whether a calibration can be finished at that spot.

Your claim and your choice

A windshield is normally a comprehensive claim in North Carolina, paid less your deductible, and the state has no law that waives the glass deductible. Some policies include full glass coverage. Under G.S. 58-3-180 you pick the repair service and the insurer pays the same amount either way; an insurer that recommends a shop must tell you that you do not have to use it. Impex works with all major insurance providers and can handle the claim.

Nearby pages

South of the causeway, Cornelius auto glass covers Cornelius and Davidson and windshield replacement in Huntersville covers the next town down I-77. The full visit is explained on mobile windshield replacement in Charlotte, and Denver is on the service areas page.

Questions drivers ask